Recent human-in-the-loop (HIL) optimization studies using wearable devices have shown an improved average metabolic reduction by optimizing a small number of control parameters during short-duration walking experiments. However, the slow metabolic dynamics, high measurement noise, and experimental time constraints create challenges for increasing the number of control parameters to be optimized. Prior work applying gradient descent and Bayesian optimization to this problem have decoupled metabolic estimation and control parameter selection using fixed estimation intervals, which imposes a hard limit on the number of parameter evaluations possible in a given time budget. In this work, we take a different approach that couples estimation and parameter selection, allowing the algorithm to spend less time on refining the metabolic estimates for parameters that are unlikely to improve performance over the best observed values. Our approach uses a Kalman filter-based metabolic estimator to formulate an optimal stopping problem during the data acquisition step of standard Bayesian optimization. Performance was analyzed in numerical simulations and in pilot human subject testing with two subjects that involved optimizing six control parameters of a single-joint exosuit and four parameters of a multi-joint exosuit.

We present an autonomous and portable hip-only soft exosuit, for augmenting human walking and running that assists hip extension by delivering peak forces of 300N to the user. Different fixed assistance profiles for walking and running were applied based on an online classification algorithm. The approach is based on the biomechanical understanding that the center of mass potential energy fluctuations during walking and running are out of phase. Specifically, we monitor the vertical acceleration with an abdomen-mounted IMU at the moment of maximum hip extension. Validation is demonstrated with six subjects on the treadmill and with eight subjects outdoors. Our results demonstrated a 99.99% accuracy on average over the fourteen participants for various speeds (0.5 - 4m/s), slopes (-10 -20%), treadmill and overground terrain, loaded (13.6 kg) and unloaded, Exo On and Exo Off conditions, and different shoe types. Results from an evaluation outdoors overground on the energetics of eight subjects demonstrated a significant reduction for running when comparing Exo On to No Exo (3.9%) and for walking and running when comparing Exo On to Exo Off (12.2% and 8.2% respectively). This study represents the first demonstration of an autonomous wearable robot reducing the energy cost of running. Significant variation in response across subjects was observed, highlighting further improvements may be possible via assistance profile individualization with human-in-the-Ioop optimization.

Soft exosuits are a new approach for assisting with human locomotion, which applies assistive torques to the wearer through functional apparel. In this paper, we present a new version of autonomous multi-joint soft exosuit for gait assistance, particularly designed for overground walking. The soft exosuit assists with ankle plantarflexion, hip flexion, and hip extension, equally distributing the forces between ankle plantarflexion and hip flexion. A mobile actuation system was developed to generate high assistive forces, and Bowden cables are used to transmit the forces to the exosuit. A sensor harness connects two load cells and three IMU s per leg that are used to measure real-time data for a controller that commands desired force profiles as a function of the walking cycle. In addition, a control adaptation method was developed which adjusts control parameters while walking on irregular surfaces. In preliminary studies, the proposed method substantially improved the force consistency while walking over uneven terrain. Specifically, the number of steps where the peak force deviated from the target force decreased from 100 to 57 out of 250 steps, and RMS error on the peak force decreased from 90.0 N to 76.6 N with respect to 300 N target force. Also, a two-subject case study on country-course walking demonstrated the potential of this soft exosuit to improve human energy economy while walking overground.